1

Topic: The ultimate SD4 upgrade thread

So I'm planning to do what I can to make my SD4 as good as it can be.

I've added a sheet of 3/16 glass, which was secured to the kapton-covered bed (I like the color) with Aquanet. Takes a while to pre-heat but I don't mind. Elmers glue stick has solved any lifting issues.

I'm printing new carriage assemblies ( http://www.thingiverse.com/thing:104059 ) to switch to lm8uu bearings.

Now I'm reading thru the z-axis upgrade threads and not quite sure what the *best* solution is. If I'm going to tear it apart, I'd like to do it once, so which rod should I use? M3 or M5? I've also read about different stepper motors - is that a good idea?

Help me, soliforum kenobi - you're my only hope..

Stock SD4 with 3/16" glass attached to stock (kapton-covered) bed with Aquanet.

2 (edited by slimstar2 2014-08-29 23:18:36)

Re: The ultimate SD4 upgrade thread

Hi eflyguy, Iam slimstar2 . I have had my SD3 since Xmas . the way I tightened up my printer ( X and Y shafts) was to print the heavier pulley mounts found in the forum then drill out the ends of the pulleys with a 5/16 drill bit in a drill press then insert 8 mm x 5mm x 3mm  bearings into the pulleys then reassemble as was with original nuts and bolts . I haven't had to readjust belts in months . As for the Y shaft at the back of the case I replaced the bushings with bearings. I just pressed the bushings out with a bolt and nut and some washers,and reversed them to press new bearings in. I did have to polish the rear shaft with a little sand paper and elbow grease to make bearing slide on . I got all to bearings from Bocabearings .com . I haven't had to adjust anything in months and I get nice round circles. As shown in 1 of the pictures I did have to grind just a little off of the X pulley for clearance on the LM8UU bearings I used in Lawsy's carriage upgrade. Last photo was just to show nice clean circles. Hope this helps . And may the force be with you.

Post's attachments

P8230003.JPG
P8230003.JPG 62.61 kb, file has never been downloaded. 

P8290007.JPG
P8290007.JPG 76.95 kb, file has never been downloaded. 

P8290009.JPG
P8290009.JPG 60.28 kb, file has never been downloaded. 

P8290010.JPG 76.95 kb, file has never been downloaded. 

You don't have the permssions to download the attachments of this post.
SD3, RAMPS 1.4, Lawsy's carriages modified by me, 2 SSRs, E3D V6, 2 Power supplies, Independent monitoring of both power supplies (amps and volts) also extruder and bed temps, Blue Tooth connectivity, bearings in all axis & rotational points, Y axis direct drive.  Remotely controlled power box on / off . Gecko Tec build plate . Renamed FrankenDoodle

3

Re: The ultimate SD4 upgrade thread

Interesting, thanks!

Stock SD4 with 3/16" glass attached to stock (kapton-covered) bed with Aquanet.